Product ID:DY-CHEK/FLURO-CHEK NAD DEVELOPER PSU, 01607
MSDS Date:04/04/1995
FSC:6850
NIIN:00-440-4961
MSDS Number: BYBYP

TURCO PRODUCTS INC

7320 BOLSA AVE
WESTMINSTER, CA 92684
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 714-890-3600

Preparer: JOHN F. GRAINGER

Cage: 61102

TURCO PRODUCTS, INC. DIVISON OF ELF ATOCHEM NORTH AMERICA

PHILADELPHIA, PA 19103-3222 US

Telephone: 215-419-7890

Cage: 61102

ETHANE, 1,1-DICHLORO-1-FLUORO-; (DICHLOROFLUOROETHANE)

CAS: 1717-00-6

RTECS: KI0997000

Fraction By Weight: 40%

OSHA PEL N/K

ACGIH TLV: N/K

1); (CALCIUM CARBONATE)

CAS: 471-34-1

RTECS: FF9335000

Fraction By Weight: <5%

OSHA PEL N/K

ACGIH TLV: N/K

ISOPROPYL ALCOHOL; (ISOPROPANOL) (SARA 313)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 15%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM; 500 STEL

1,1,1,2-TETRAFLUOROETHANE

CAS: 811-97-2

OSHA PEL N/K

ACGIH TLV: N/K

ALUMINUM HYDROXIDE; (HYDRATED ALUMINA)

CAS: 21645-51-2

RTECS: BD0940000

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:CHLOROFLUOROCARBON (CFC) MATLS HAVE
PRDCED SENSIT OF MYOCARDIUM TO EPINEPHRINE IN LAB ANIMALS & COULD
HAVE SIMILAR EFT IN HUMANS. ADRENOMIMETICS (IE, EPINEPHRINE) MAY BE
CONTRA-INDICATED EXCEPT FOR LI FE-SUSTAINING USES IN HUMANS
ACUTELY/CHRONICALLY EXPOSED TO CFCS . EYES: CNTCT W/VAP MAY CAUSE
MOD TO SEV IRRIT. CNTCT W/LIQ MAY CAUSE SEV IRRIT. SKIN: CNTCT MAY
CAUSE MOD TO SEV IRRIT. INHAL: V APS:HDCH, NAUS, VERTIGO. MISTS:MOD
TO SEV IRRIT OF RESP TRACT. INGEST: MOD TO SEV IRRIT OF GI TRACT.
MAY BE HARMFUL IF SWALLOWED. TOX EFTS MAY NOT APPEAR IMMED. OVEREXP
TO CHLORINATED OR FLUORINATED ( EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: HYDROCARBS MAY CAUSE CARD
IRRITABILITY &/OR LEAD TO CARD ARRHYTHMIA. DELIB ABUSE BY
CONCENTRATING & INHALING VAPORS MAY LEAD TO SEVERE KIDNEY & LIVER
DAMAGE.
Medical Cond Aggravated by Exposure:OVEREXPOSURE TO CHLORINATED OR
FLUORINATED HYDROCARBONS MAY CAUSE CARDIAC IRRITABILITY &/OR LEAD
TO CARDIAC ARRHYTHMIA AGGRAVATING ANY PREEXISTING CARDIAC DAMAGE OR
DYSFUNCTION.

First Aid:EYES: IMMED BEGIN FLUSHING W/LG VOLS OF WATER. CONTINUE FOR
AT LEAST 15 MIN. HOLD LIDS APART TO ASSURE CNTCT W/ALL SURFS.
OBTAIN MED ATTN. SKIN: SPEED IS ESSNTL. FLUSH AFFECTED AREA W/LG
VOLS OF WATER . WASH W/SOAP & WATER. RINSE THORO. IF IRRIT IS
EVIDENT/BLISTERS OCCUR, OBTAIN MED ATTN. INHAL: REMOVE TO FRESH
AIR. IF BRTHG IS DFCLT, ADMIN OXYGEN. IF BRTHG HAS STOPPED, APPLY
ARTF RESP. OBTAIN MED ATTN. INGEST: DO NOT INDUCE VOMIT EXCEPT ON
ADVICE OF COMPETENT MED PERS. IF CONSCIOUS, DILUTE BY GIVING LG
VOLS OF MILK OR WATER. OBTAIN IMMED MED ATTN. NEVER ATTEMPT TO
INDUCE VOMIT/GIVE ANYTHING BY MOUTH TO AN UNCON PERSON.

Flash Point:NONFLAMMABLE
Extinguishing Media:CARBON DIOXIDE, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA
AND FULL PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:THERMAL DECOMP PRODS MAY INCL FLUORIDES,
CHLORIDES & PHOSGENE. CONTENTS UNDER PRESS. HEATING ABOVE 120F MAY
CAUSE CNTNRS TO BURST. THERMAL DECOMP OF CONTENTS MAY PRDCE TOX
OXIDES OF CARBON, NITR OGEN & CHLORINE, ACID GASES &/OR OTHER TOX
VOLAT ORG CMPDS.

Spill Release Procedures:CONCENTRATE: RELIEVE PRESSURE ON LEAKING
CONTAINERS BY IMMEDIATE USE OR EMPTY BY SPRAYING ONTO ABSORBENT
MATERIAL. DISPOSE OF EMPTIED AEROSOL SPRAY UNITS. USE SOLUTION: NOT
APPLICABLE. THIS PRODUCT IS USED AS RECEIVED.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN COOL, DRY PROTECTED AREA AWAY
FROM SOURCE OF EXCESSIVE HEAT.
Other Precautions:NO SMOKING IN AREA OF USE. DO NOT USE IN THE GENERAL
VICINITY OF ARC WELDING, OPEN FLAMES OR HOT SURFACES. HEAT AND/OR
UV RADIATION MAY CAUSE THE FORMATION OF CHLORIDES, FLUORIDES OR
PHOSGENE .

Respiratory Protection:IF TLV IS EXCEEDED, A NIOSH/MSHA APPROVED SCBA,
POS PRESS HOSE MASK OR AIR LINE MASK IS ADVISED. THESE SHOULD HAVE
FULL FACE PIECE & BE OPERATED IN POS PRESS MODE. FOR LIMITED EXPOS
TIME, IN AREAS OF GOOD VENT, FULL FACE MASK WITH ORG VAP CARTRIDGE
OR CANISTER MAY BE USED. THESE MUST NOT BE USED IN ANY AREAS WHERE
DANGER OF OXYGEN DEFICIENCY EXISTS (SUPDAT)
Ventilation:MAINTAIN SUFFICIENT MECHANICAL VENTILATION TO KEEP
CONCENTRATION BELOW TLV.
Protective Gloves:SOLV RESISTANT (E.G. NEOPRENE, VITON).
Eye Protection:ANSI APPROVED CHEMICAL WORKERS GOGGLES AND FULL LENGTH
FACESHIELD .
Other Protective Equipment:ANSI APPRVD EMER EYE WASH & DELUGE SHOWER .
BOOTS & APRON OF SOLV RESIST MATL (E.G. NEOPRENE, VITON). PROT SUIT
NOT NORMALLY REQD BUT ADVISED IF NEC TO AVOID PRLNG/RPTD SKIN
CTNCT/OTHER EXPOS.
Work Hygienic Practices:WASH HANDS & FACE W/SOAP & WATER BEFORE
SMKNG/EATING. IMMED REMOVE ALL CONTAMD CLTHG. LAUNDER SEPARATELY
BEFORE REUSE.
Supplemental Safety and Health
RESP PROT: SUCH AS PARTLY ENCLSD OR LOW LYING AREAS, INCL SUMPS/TANKS.
IF RESPS ARE USED, FORMAL TRAINING & SCREENING PROGRAM MUST BE
INITIATED. SEE 29 CFR 1910-134.

Boiling Pt:B.P. Text:120F,49C
Vapor Pres:300
Vapor Density:>1
Spec Gravity:1.33
Evaporation Rate & Reference:>1 (BUAC=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:RAPIDLY DRIES TO WHITE POWDERY COATING WHEN
SPRAYED; ALCOHOL ODOR.
Percent Volatiles by Volume:95

Stability Indicator/Materials to Avoid:YES
CONTACT WITH STRONG OXIDIZING AGENTS, STRONG ACIDS, STRONGLY HEATED
REACTIVE METALS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:CHLORIDES, FLUORIDES & PHOSGENE. TOX
OXIDES OF CARBON, NITROGEN & CHLORINE, ACID GASES, OTHER TOX VOLAT
ORG CMPDS.

Waste Disposal Methods:CONC:(1) TRANSFER TO RECLAIMING CTR FOR
RECYCLING/REUSE IF POSS. (2) TRANSFER TO LICENSED HAZ WATER
TREATMENT/DISP SITE FOR DISPOSITION UNDER APPLIC LOC, STATE,
REGIONAL & FED REGS AS HAZ WASTE. IT MA Y BE NEC TO EMPTY SPRAY
CANS & PUNCTURE THEM BEFORE DISP. TRIPLE RINSING MAY ALLOW DISP AS
NONHAZ WA STE. SPENT SOLN & RINSES:NOT APPLICABLE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.